5012 Synthesis of acetylsalicylic acid (aspirin) from salicylic acid
and acetic anhydride
Reaction types and substance classes
reaction of the carbonyl group in carboxylic acid derivatives, esterification carboxylic acid anhydride, carboxylic acid ester, carboxylic acid, phenol, aromatics, acid Work methods
microwave-assisted reaction, stirring with magnetic stir bar, heating under reflux, filtering, extracting, shaking out, recrystallizing Instruction (batch scale 100 mmol)
Microwave system ETHOS 1600, glass tube (40 cm, NS 29), 100 mL two-neck flask, magnetic stirrer, magnetic stir bar, intensive cooler, glass frit (diameter 6 cm), suction flask, Substances
aqueous iron(III) chloride solution (0.1 M) Reaction
The reaction apparatus consists of a 100 mL two-neck flask with magnetic stir bar, temperature sensor and intensive cooler. A mixture of 13.8 g (100 mmol) salicylic acid and 12.8 g (11.9 mL, 125 mmol) acetic anhydride is filled in the reaction flask and three drops of conc. sulphuric acid are added. The apparatus is installed by means of a glass tube in the microwave system (see "Technical Instructions. Standard refluxing apparatus for microwave system"). The reaction mixture is heated under stirring for 90 seconds with 900 W to 140 °C. During the following cooling down the clear yellowish solution solidifies to a compact white After cooling down to room temperature, the solid is chopped in the flask and stirred for 30 minutes with 50 mL water. Then the solid is sucked off over a glass frit. The filter residue is washed on the frit three times with 30 mL water each, thereby the washing water runs through without vacuum, finally, it is thoroughly sucked off. The filtrate is disposed. The crude product on the frit is analyzed with a 0.1 M iron(III) chloride solution for possibly contained salicylic acid (see analytics). If the test result is negative, the product is dried in the desiccator over granulated sodium hydroxide under reduced pressure until mass constancy. During the drying procedure also still adherent acetic acid is removed. Yield: 16.0 g (88.8 mmol, 89%); mp 136 °C For further purification, i.e. if the product still contains salicyl acid, it is recrystallized from ethanol/water: The crude product is dissolved under heating in about 30 mL ethanol, then about 60 mL hot water are added through the reflux condenser. The mixture is slowly cooled down and the flask is put in an ice bath to complete the crystallization. The product is sucked Yield: 14.6 g (81.0 mmol, 81%); mp 136 °C Comments
Without addition of sulphuric acid the yield of the crude product amounted to about 83%, still containing bigger volumes of salicylic acid. After recrystallization the yield was below 70%. If the humid product is pre-dried on a filter paper under the hood, considerably less drying Waste management
Waste disposal
Waste Disposal
Degree of difficulty
Temperature-time-dependence of the reaction steps in the microwave field
Synthesis of the acetylsalicylic acid
Temperatur [°C]
Zeit [sec]
Iron(III) chloride test
About 10 mg of the substance are dissolved in about 5 mL ethanol and 1 to 2 drops of a 0.1 M aqueous iron(III) chloride solution are added. An intensive violet colour of the solution shows Gas chromatography is not applicable as analysis method, since both salicylic acid as well
as the product decarboxylate on the GC column.
1H NMR spectrum of the product (300 MHz, CDCl3)
Multiplicity Number

13C NMR spectrum of the product (300 MHz, CDCl3)
IR spectrum of the product (KBr)
(cm-1) Assignment
O-H-valence, carboxylic acid, superimposed by


Microsoft word - lyme disease prevention tips 2.12.doc

Who is at risk for Lyme disease? Cutter© Backwoods, Ultrathon™, etc). Ultrathon™ time-release Outdoor workers, gardeners, campers, hikers, people who hunt, formulations provide extended protection. Non-DEET repellents, fish, golf, or picnic in parks, or children on a school nature outing include BioUD™ (®.html) , Natrapel® are all at risk. Children are espe

Wet pet gazette y2001 issue

The Journal of the Norwalk Aquarium Societyregulations, and species we may find. Whether you are interested in native fishes,just want to get out of the house, or simply From Up-front want to watch everyone splashing around inthe water, this can be an excellent way tospend a day. This trip will be held on the DEPfree fishing day in early June. Further detailshas already been working to

Copyright © 2010-2014 Metabolize Drugs Pdf